After the attack on the car factory, it took a month to initially resume production. There is still a large amount of equipment that needs to be repaired and debugged, and many buildings are also bumpy. It is expected to take more than three months to restore production capacity.
Although the recovery time is not short, fortunately it is an automobile factory. If Xincheng Heavy Industry and Gold Chemical Industry were damaged, the situation would be worse.
Xincheng Heavy Industry is a precision manufacturing plant for production equipment, and it has extremely high requirements for the assembly of machinery. At a certain point, a 20mm cannon bullet may be fired to the ground, and the equipment a hundred meters around will have to be re-adjusted. And their The overall production complexity is higher than that of an automobile factory, and it is difficult to partially resume production.
Gold Chemical is related to the supply of butyl rubber. This technology has official subsidies and therefore stipulates an exclusivity period. However, even if the exclusivity period passes, it will be extremely difficult to spread the technology.
Butyl rubber, like polyethylene materials, is produced by low-temperature polymerization of petroleum gas after separation according to demand. A set of oil refining equipment is required in the front. To achieve certain economic benefits, additional cracking is required, which not only converts part of the refined oil and The heavy oil is converted again to reduce the production rate of heavy oil and asphalt and increase the proportion of petroleum gas.
The production cost of this entire set of equipment is extremely high. The higher the capital density, the greater the threat from mysterious criminal damage. It requires heavy protection, which is basically unrealistic overseas.
If the scale is reduced and the petroleum refining system is removed, it will be smaller, and the scale of the security company will be enough to take care of it. However, if there is no petroleum gas refining capacity, separation gas must be specially purchased. The problem is that butyl rubber is now in short supply, and where will the gold heavy industry find leisure? Kung Fu specializes in producing separation energy for others?
Setting up a new petrochemical industry within the country is very troublesome due to insufficient domestic demand, limited transportation capacity, and inability to digest many things.
The entire system is still fragile to a certain extent, so it is lucky that the car manufacturers are the ones that are hit.
However, from the enemy's perspective, there is nothing wrong with targeting the automobile factory as the first target.
Among the three automobile factories in the country, Xincheng Automobile Factory is not the largest in terms of production volume, but it is far ahead in terms of calculated tonnage. It is the right choice to attack the transportation industry.
The aircraft manufacturing industry also has three factories, but their protection strength is also very high visible to the naked eye. In addition, the requirements of the aircraft manufacturing site also make the factory area relatively empty, making it more difficult to attack.
Xincheng Heavy Industries, which does not take the initiative to solicit business at all, cannot compare with Fenggu Industrial Zone in terms of equipment shipments, and its presence is quite low. Not to mention the demons, many people in the territory do not realize that it is the heart of the entire production chain. .
As for the gold chemical industry, it's really just luck. If you do more careful intelligence work, you can still easily notice that the amount of rubber and plastic is constantly increasing.
As a king, Wang Qi does not value the loss of one place, but he cannot cause the entire industrial chain to stop because of the destruction of one place. Once such a situation occurs, the border defense line will not last long and will become a sieve.
Metro Heavy Industries' backup is already being done.
One of them is the entire Wind Valley Industrial Area.
The largest parts supplier in the Fenggu Industrial Zone is called Kobelco Forging. It is a cooperation between the local machinery factory and Kemp Precision Manufacturing, formerly known as the Fenggu Aircraft Factory. It is based on the forging plant affiliated to the steel plant as the site. was established to mainly provide various mass-produced parts that are in high demand for non-specialty steel processing. It alone covers an area of 30 hectares, more than 50 workshops, and nearly 200 production lines for different parts.
In addition to automobile factories, electrical machinery factories, and various large and small production plants, they have been able to produce some production equipment by themselves through internal coordination.
Although the processing equipment cobbled together in this way will have some faults and the accuracy is relatively weak, it is more friendly to many small manufacturers with insufficient scale and insufficient funds. In addition, for overseas businessmen, even if they know the name of Xincheng Heavy Industries, no one will pay attention to them if they want to buy it, so they can only make do with it.
However, this set of replacements cannot be replaced after the destruction of Xincheng Heavy Industry. Even repairing and debugging the original equipment will be difficult.
Therefore, a system developed by Metro Heavy Industries itself is still needed.
The motorcycle factory and the automobile factory can barely be considered a member of this system. They also have the strength to convert into production equipment, but geographically these groups are all together, so there is no need to separate them.
There is only one way to meet the needs of safety and complete replacement after disasters, as well as the overall technical personnel gap in the manufacturing industry.
Mothballing a brand new Xincheng Heavy Industry.
The specific method is to give them a complete set of workshops and backup equipment under the water surface of the central reservoir.
A factory placed on the surface but not producing anything can easily arouse suspicion, especially since the attack on the automobile factory failed this time. The demons may use more advanced spies. This anomaly can be easily noticed.
It is really wasteful to dedicate a group of soldiers and equipment to protect a factory that is not producing.
If you put it in a reservoir, there will be no such problems. The entire water body of the reservoir is under the control of the giant sacred tree. All the creatures in it are food for Little Bear City. Even if outsiders are invisible, they cannot hide from the people all over the reservoir in the water. Predation sensor.
The ceiling of the spare factory does not need to be directly connected to the ground and underwater safety layer. The entrance and exit can be transferred to the surface along the original mountain topography of the reservoir area, ensuring that the entrance and exit can be directly targeted by the army.
The sacred tree is alive. After the factory buildings and equipment are installed and sealed, the entrances and exits can even be sealed to exhaust most of the air. It can also be changed to a lifting type like the south square of the administrative center.
The problem of wood not being able to withstand high temperatures is easy to deal with. When Wang Qi conceived Little Bear City in his early days, he had considered the need for a certain production capacity in a giant city and had already prepared a heat insulation plan.
Using a mesh grille metal floor and cooling water pipes is actually the workshop cooling solution of a normal steelmaking plant. The difference is that wood is more fragile and requires greater water flow and a denser pipe network to ensure that high temperatures do not dehydrate wood cells.
In contrast, it is more troublesome for Gold Chemical to make backups.
Two questions.
Chemical industry has a lot of chemicals and raw materials. It is too difficult to design a ventilation system when playing this underwater. Moreover, chemical plants require a huge amount of welding operations due to corrosion and pipeline length problems, which will also produce some hazardous gases.
Another characteristic trouble of the petrochemical industry is pipeline blockage.
When the oil production process is shut down due to any problems, the first thing to do after maintenance is to heat the pipes everywhere to let the solidified things in the pipes flow. This means that if you back up a chemical plant underwater, try not to stop it once it is started. This will further increase the risk of chemical substances and toxic gases.
If it starts for a few days and stops for a month or two, then it is better to find a bunch of alchemists to refine it in glass jars. Maybe it will be faster overall.
Therefore, chemicals cannot be placed underground or underwater.
It would be best to come up with a miniaturized fool-like device. For some things that are difficult to implement, consider using magic. The size can be carried on a train. It can be placed in a warehouse at ordinary times. When used, it can be used in emergency situations without affecting market supply and demand.
Really consider the train backup system. There are really a lot of things that can be done. I don’t have the energy for the moment, so I will put everything else aside first.
